10.14489/td.2022.09.pp.014-022

2022, 09 September

DOI: 10.14489/td.2022.09.pp.014-022

Danilov V. N.
ON THE INFLUENCE OF THE PARAMETERS OF THE ELECTRIC EXCITATION PULSE OF A PIEZOELECTRIC PLATE OF A NORMAL PROBE ON THE CHARACTERISTICS OF THE FREQUENCY SPECTRUM AND PULSE OF THE RECORDED ECHO SIGNAL
(pp. 14-22)

Abstract. On the basis of computer modeling of the electro acoustic channel of a normal probe for a reflector in the form of a bottom surface, the influence of some typical forms and corresponding frequency spectra of the electric pulse of excitation of the piezoelectric plate on the characteristics of the frequency spectrum and pulse of the recorded echo signal is considered. Calculations of signals using an exciting pulse in the form of a voltage jump (step), in the form of half a sine wave and a rectangular shape have shown the feasibility of using rectangular pulses with a duration equal to half of the oscillation period at the nominal frequency of the probe. The maximum of the pulse envelope of the recorded bottom echo for the excitation pulse of a rectangular shape piezoelectric plate is approximately twice as high as the maximum of the envelope when the piezoelectric plate is excited by a pulse in the form of a jump and a quarter more than the maximum when excited by a semi sinusoidal pulse for the nominal frequencies of the probes 2.5 and 5.0 MHz.

Keywords: normal probe, pulse shape, rectangular shape, signal spectrum, electro acoustic channel, echo signal, oscillation period, piezoelectric plate.

+ - About the Authors Click to collapse

V. N. Danilov (JSC “RPA “CNIITMASH”, Moscow, Russia) E-mail: Данный адрес e-mail защищен от спам-ботов, Вам необходимо включить Javascript для его просмотра.

+ - References Click to collapse

1. Ermolov I. N., Lange Yu. V. (2006). Ultrasonic control. Non-destructive testing: reference book: in 8 volumes. Vol. 3. 2nd ed. Moscow: Mashinostroenie. [in Russian language]
2. Ermolov I. N., Gitis M. B., Korolev M. V. et al. (1986). Ultrasonic transducers for non-destructive testing. Moscow: Mashinostroenie. [in Russian language]
3. Korolev M. V., Karpel'son A. E. (1982). Broadband ultrasonic transducers. Moscow: Mashinostroenie. [in Russian language]
4. Danilov V. N., Izofatova N. Yu., Voronkov V. A. (1997). Comparison of theoretical and experimental results of the study of the operation of direct combined converters. Defektoskopiya, (6), pp. 39 – 49. [in Russian language]
5. Danilov V. N. (2022). About influence of the parameters of the electrical circuits of transmission and reception of a single crystal normal probe on the characteristics of the frequency spectrum and the pulse of the bottom echo. Kontrol'. Diagnostika, (5), pp. 4 – 11. [in Russian language] DOI: 10.14489/td.2022.05.pp.004-011
6. Titchmarsh E. Ch. (1948). Introduction to the theory of Fourier integrals. Moscow–Leningrad.: Gostekhizdat. [in Russian language]
7. Shimoni K. (1964). Theoretical electrical engineering. Moscow: Mir. [in Russian language]
8. Danilov V. N. (2006). The program for computer simulation of the operation of electroacoustic paths of flaw detectors "IMPULSE +". Defektoskopiya, (3), pp. 37 – 43. [in Russian language]

+ - Purchase digital version of a single article Click to collapse

This article is available in electronic format (PDF).

The cost of a single article is 500 rubles. (including VAT 20%). After you place an order within a few days, you will receive following documents to your specified e-mail: account on payment and receipt to pay in the bank.

After depositing your payment on our bank account we send you file of the article by e-mail.

To order articles please copy the article doi:

10.14489/td.2022.09.pp.014-022

and fill out the form